Officials blame Ottawa LRT shutdown on 'unique' ice buildup

Freezing rain forced 6-day LRT shutdown City officials suggest unexpected ice buildup sent LRT out of service for six days in January. CTV's Leah Larocque reports.

More than a month since a section of Ottawa’s LRT system shut down for six days after a freezing rainstorm, officials have revealed the cause of the outage.

The short answer: it was ice.

But how the ice got there, officials said, was due to a “unique combination of factors.”

Those factors led to two trains on the Confederation Line, one eastbound and one westbound, getting stuck near Hurdman Station. Two trains later sent to help also got stuck.

The city and its LRT contractor Rideau Transit Maintenance said they are exploring several options—from anti-icing treatments to a rescue diesel train—to stop a similar outage from happening again.

It is not clear why, after four years of operating the system, some of the ice mitigation strategies have not been put in place.

‘Unique’ weather conditions

The city’s transit commission heard details for the first time on Thursday about what exactly led to the shutdown in early January.

The six-day shutdown happened when some freezing rain caused buildup on the overhead wire that powers the trains between Hurdman and Lees stations. Service still ran on parts of the line farther east and west.

Richard Holder, the city’s director of engineering, said specific conditions at the time led to more ice buildup on the wires than usual.

The Rideau River was ice-free due to a warmer-than-usual start to January, he said. That led to high levels of humidity in the area, which led to further accumulation on top of the freezing rain. This all led to ice quickly building up on the overhead catenary wire that powers the trains, he said.

“This unique combination of factors caused greater ice building in that area than elsewhere on the system,” Holder said. “We’re very certain that this occurred because of the accumulated ice on the OCS contact wire.”

Contact wire ‘melted’

When recovery trains were dispatched later, they were forced to go slowly, which resulted in a lot of electrical arcing on a small section of the contact wire.

“Normally when a vehicle is moving fast and you get arcing, the arcing event is spread out over a larger area, with the vehicles basically stationary that arcing all occurred in the same section, creating a huge amount of energy, a huge amount of heat generated,” he said.

“The contact wires basically melted,” Holder said.

Crews then had to spent several days clearing ice off the wires and then fixing the wires. They broke ice by hand off about 5.6 kilometres of the line, from uOttawa station all the way to Tremblay station.

“That breaking of the ice, and when I say by hand, it is literally somebody in a high-rail vehicle on a bucket breaking the ice off by hand,” he said.

And while repairing the wires only took a few hours, he said a full inspection of the system took several days.

City looking into diesel rescue train

The city and Rideau Transit Maintenance have established a working group on the overhead wires.

Certain changes have already been made. The city is installing winter carbons on light rail vehicles, Holder said.

“Those are a brass insert installed into the pantograph, which have a more aggressive metal edge and are able to break through and shear off the ice accumulation,” he said.

OC Transpo will also “strategically” place staff on the line for monitoring ice buildup and arcing, he said. And a new onboard train diagnostic system will give advance warning for issues happening with the vehicle, such as voltage drops.

Down the line, the city is also investigating use of anti-icing treatments to be used on the contact wires in advance of freezing rain, Holder said. The Toronto Transit Commission uses such a system.

“They have a pretty extensive program for their trams where they have vehicles out on the street continually spraying anti-freezing agents onto the OCS,” he said.

They are also looking at procuring a diesel recovery train, which wouldn’t be affected by problems with the overhead wire.

“I’m kind of shocked we don’t have one of those yet,” Coun. Tim Tierney told transit commission.

RTM head Mario Guerra said they are already looking for such a vehicle.

“You can appreciate our system is unique in terms of the envelope, so it’s going to prove difficult to get something off the shelf that would fit into our system,” he said. “But we also have some equipment here that we think we might be able to alter for that purpose.”