Fix to software problem behind naval helicopter crash needed 'forthwith': experts
The software issue identified as a cause of last year's naval helicopter crash off Greece that killed six Canadian crew members needs to be fixed without delay, say experts on the interplay between automation and humans in aircraft.
Two internal reviews by the Canadian Armed Forces found the autopilot took control of the CH-148 Cyclone helicopter, plunging it into the Ionian Sea as the pilot was turning to return to HMCS Fredericton on April 29, 2020.
Master Cpl. Matthew Cousins, Sub-Lt. Abbigail Cowbrough, Capt. Kevin Hagen, Capt. Brenden MacDonald, Capt. Maxime Miron-Morin and Sub-Lt. Matthew Pyke died in the crash.
Mary (Missy) Cummings, an engineer and former U.S. navy pilot, reviewed the Flight Safety Investigation Report, the second of two reports by the military, after its release June 28. Cummings, director of the humans and autonomy lab at Duke University, called the pilot's inability to regain control from automated software "a very serious problem."
"This needs to be addressed forthwith. It should be fixed, bottom line. Who bears the costs, that's up to the lawyers to decide," she said in a recent video interview from Durham, N.C.
She said the automation on the aircraft is flawed. "There is known confusion for pilots, and instead of addressing this problem head on, people are trying to make excuses for either how the system is or was designed," she said.
"It's very likely that another fatality is going to happen if they don't address this problem."
According to the two reports' findings, theautopilot was left on as the pilot executed a sharp turn, and as a result the software built up commands, preventing the pilot from resuming manual control at the end of his turn. The first military report -- the Board of Inquiry report -- referred to this accumulation of calculations from the automated software as "attitude command bias."
The Board of Inquiry report said these commands in the software "can accumulate to such a degree that it severely diminishes, or even exceeds," the pilot's ability to control the aircraft manually.
"It wasn't a hotdog manoeuvre," said Cummings, a former director of the U.S. navy's advanced autonomous rotorcraft program. "So something was wrong with the software code base, and if it were me, and I was in the Canadian military, I would stop everyone from using autopilot until I got this problem fixed."
Greg Jamieson, a professor of industrial engineering at the University of Toronto who studies human-automation interactions, said the software issue "is a present safety issue that the Defence Department needs to immediately address with Sikorsky."
"Of course, you don't tell someone to change code and put it in helicopters next week. Yes, it takes time ... but that process must be started immediately," he said in a recent interview, adding he hesitates to advocate suspending use of the autopilot until the fix is completed.
The military responds that the aircraft manufacturer, Sikorsky, a subsidiary of Lockheed Martin, and the Royal Canadian Air Force have done a thorough exploration of the ways similar problems might emerge and have concluded the aircraft is safe.
In an emailed statement sent July 16, Defence Department spokeswoman Jessica Lamirandesaid that as a result of a detailed assessment, the aircraft is being modified to make pilots more aware of when they're using autopilot and to provide more warning signals for the flight crew.
As for a fix to the software issue, Lamirande wrote that the military is working with Sikorsky to "determine the exact parameters of how to implement this modification."
"The Cyclone is a complex system, and we need to make sure that, by introducing this change, we are not causing adverse or unintended issues to other parts of the system," she said. She called the change "a very high priority modification for the fleet" that will be completed as soon as possible.
She added that in the meantime, the Royal Canadian Air Force has trained the aircrews to ensure they are aware of the scenario that led to the crash and understand how to avoid it or recover from it.
"We also made some changes to the aircraft documentation, and it now provides clearer warnings, restrictions, and limitations for the aircrew," she wrote.
However, Cummings said she remains concerned, in part because the military failed to catch the problem in certification processes. She said the situation that led the Cyclone to crash was foreseeable.
"We know that pilots tend to override automated controls with them left on," she said. "There's a whole series of accidents in the 1990s that we teach where humans will intervene when the automation is engaged, not realizing that this is the case."
Ella Atkins, an aeronautical engineer and computer scientist at the University of Michigan, agreed that the software issue should be fixed immediately.
"It is likely if they (aircrew) used the same flight control laws for aggressive manoeuvres that aren't quite like this one, it would cause the same problem," she said in a telephone interview.
Jamieson said he felt the publicly released "accumulation bias" description in the Flight Safety Investigation Report was unclear, and there wasn't sufficient information provided on it.
"It's almost treated as this mysterious force that acts on the aircraft. It's not an engineering description. We don't have an engineering description of this error, and that concerns me very deeply," he said.
John Dorrian, a spokesman for Sikorsky, said in an email the company defers to the comments from the Department of National Defence.
Dorrian said in an earlier comment to The Canadian Press that when the helicopter is operated "as designed, tested, and certified, the CH-148 has proven to be safe and effective," adding, "If requested, we are ready to work with the Canadian Armed Forces to modify the CH-148."
The crash was the largest single-day loss of life for Canada's military since Afghanistan. It also cast a harsh spotlight on the Cyclone's long and problem-plagued development, which remains a work in progress.
Sikorsky is yet to deliver all 28 Cyclones that Canada first ordered in 2004, though the Defence Department says the last one is scheduled to arrive in the country by the end of this year.
This report by The Canadian Press was first published July 27, 2021.
IN DEPTH
'One of the greatest': Former prime minister Brian Mulroney commemorated at state funeral
Prominent Canadians, political leaders, and family members remembered former prime minister and Progressive Conservative titan Brian Mulroney as an ambitious and compassionate nation-builder at his state funeral on Saturday.
Trudeau, key election players to testify at foreign interference hearings. What you need to know
The public hearings portion of the federal inquiry into foreign interference in Canadian elections and democratic institutions are picking back up this week. Here's what you need to know.
Who is supporting, opposing new online harms bill?
Now that Prime Minister Justin Trudeau's sweeping online harms legislation is before Parliament, allowing key stakeholders, major platforms, and Canadians with direct personal experience with abuse to dig in and see what's being proposed, reaction is streaming in. CTVNews.ca has rounded up reaction, and here's how Bill C-63 is going over.
As Poilievre sides with Smith on trans restrictions, former Conservative candidate says he's 'playing with fire'
Siding with Alberta Premier Danielle Smith on her proposed restrictions on transgender youth, Conservative Leader Pierre Poilievre confirmed Wednesday that he is against trans and non-binary minors using puberty blockers.
TREND LINE What Nanos' tracking tells us about Canadians' mood, party preference heading into 2024
Heading into a new year, Canadians aren't feeling overly optimistic about the direction the country is heading, with the number of voters indicating negative views about the federal government's performance at the highest in a decade, national tracking from Nanos Research shows.
Opinion
opinion Don Martin: Gusher of Liberal spending won't put out the fire in this dumpster
A Hail Mary rehash of the greatest hits from the Trudeau government’s three-week travelling pony-show, the 2024 federal budget takes aim at reversing the party’s popularity plunge in the under-40 set, writes political columnist Don Martin. But will it work before the next election?
opinion Don Martin: The doctor Trudeau dumped has a prescription for better health care
Political columnist Don Martin sat down with former federal health minister Jane Philpott, who's on a crusade to help fix Canada's broken health care system, and who declined to take any shots at the prime minister who dumped her from caucus.
opinion Don Martin: Trudeau's seeking shelter from the housing storm he helped create
While Justin Trudeau's recent housing announcements are generally drawing praise from experts, political columnist Don Martin argues there shouldn’t be any standing ovations for a prime minister who helped caused the problem in the first place.
opinion Don Martin: Poilievre has the field to himself as he races across the country to big crowds
It came to pass on Thursday evening that the confidentially predictable failure of the Official Opposition non-confidence motion went down with 204 Liberal, BQ and NDP nays to 116 Conservative yeas. But forcing Canada into a federal election campaign was never the point.
opinion Don Martin: How a beer break may have doomed the carbon tax hike
When the Liberal government chopped a planned beer excise tax hike to two per cent from 4.5 per cent and froze future increases until after the next election, says political columnist Don Martin, it almost guaranteed a similar carbon tax move in the offing.
CTVNews.ca Top Stories
'They needed people inside Air Canada:' Police announce arrests in Pearson gold heist
Police say one former and one current employee of Air Canada are among the nine suspects that are facing charges in connection with the gold heist at Pearson International Airport last year.
Why drivers in Eastern Canada could see big gas price spikes, and other Canadians won't
Drivers in Eastern Canada face a big increase in gas prices because of various factors, especially the higher cost of the summer blend, industry analysts say.
Customers disappointed after email listing $60K Tim Hortons prize sent in error
Several Tim Horton’s customers are feeling great disappointment after being told by the company that an email stating they won a boat worth nearly $60,000 was sent in error.
Toronto Raptors player Jontay Porter banned from NBA
Toronto Raptors player Jontay Porter has been handed a lifetime ban from The National Basketball Association (NBA) following an investigation which found he disclosed confidential information to sports bettors, the league says.
As GC Strategies partner is admonished by MPs, RCMP confirms search warrant executed
The RCMP confirmed Wednesday it had executed a search warrant at an address registered to GC Strategies. This development comes as MPs are enacting an extraordinary, rarely used parliamentary power, summoning one of its contractors to appear before the House of Commons to be admonished publicly for failing to answer questions related to the ArriveCan app.
Woman who pressured boyfriend to kill his ex in 2000s granted absences from prison
A woman who pressured her boyfriend into killing his teenage ex more than a decade ago will be allowed to leave prison for weeks at a time.
Attempt to have murder charge quashed against alleged serial killer dismissed by judge
A motion filed by the man accused of killing four Indigenous women in Winnipeg to have one of those murder charges quashed has been dismissed by the judge – weeks before the start of his trial.
Government proposes new policy for federally regulated employees to disconnect from work
In their 2024 budget, the federal government wants to amend the Canada Labour Code, so employers in federally regulated sectors will eliminate work-related communication with employees outside of scheduled hours. If implemented, this would affect roughly 500,000 across the country.
Earthquake jolts southern Japan
An earthquake with a preliminary magnitude of 6.4 hit southern Japan late on Wednesday, said the Japan Meteorological Agency, without issuing a tsunami warning.
Local Spotlight
Marmot in the city: New resident of North Vancouver's Lower Lonsdale a 'rock star rodent'
When Les Robertson was walking home from the gym in North Vancouver's Lower Lonsdale neighbourhood three weeks ago, he did a double take. Standing near a burrow it had dug in a vacant lot near East 1st Street and St. Georges Avenue was a yellow-bellied marmot.
Relocated seal returns to Greater Victoria after 'astonishing' 204-kilometre trek
A moulting seal who was relocated after drawing daily crowds of onlookers in Greater Victoria has made a surprise return, after what officials described as an 'astonishing' six-day journey.
Ottawa barber shop steps away from Parliament Hill marks 100 years in business
Just steps from Parliament Hill is a barber shop that for the last 100 years has catered to everyone from prime ministers to tourists.
'It was a special game': Edmonton pinball player celebrates high score and shout out from game designer
A high score on a Foo Fighters pinball machine has Edmonton player Dave Formenti on a high.
'How much time do we have?': 'Contamination' in Prairie groundwater identified
A compound used to treat sour gas that's been linked to fertility issues in cattle has been found throughout groundwater in the Prairies, according to a new study.
'Why not do it together?': Lifelong friends take part in 'brosectomy' in Vancouver
While many people choose to keep their medical appointments private, four longtime friends decided to undergo vasectomies as a group in B.C.'s Lower Mainland.
Grain-gobbling bears spark 'no stopping' zone in Banff National Park
A popular highway in Alberta's Banff National Park now has a 'no stopping zone' to help protect two bears.
Deer family appears to accept B.C. man as one of their own
B.C. resident Robert Conrad spent thousands of hours on Crown land developing an unusual bond with deer.
Doorbell video shows family of black bears scared off by dog in Sudbury, Ont.
A Sudbury woman said her husband was bringing the recycling out to the curb Wednesday night when he had to make a 'mad dash' inside after seeing a bear.