Tesla Model S hits road debris and catches fire
Tesla at the Frankfurt Motor show. Unlike other electric cars, the Model S is aimed at the executive car buyer and is focused as much on performance as economy. (Photo: Tesla)
Tom Krisher, The Associated Press
Published Thursday, November 7, 2013 1:29PM EST
DETROIT -- A Tesla Model S electric car caught fire this week after hitting road debris on a Tennessee freeway, the third fire in a Model S in the past five weeks.
The blaze on Wednesday afternoon near Smyrna, Tenn., engulfed the front of the car. A spokeswoman for the Tennessee Highway Patrol says the Model S ran over a tow hitch, which hit the undercarriage of the car, causing an electrical fire.
It's the second Model S blaze involving road debris. In early October, a driver near Seattle hit debris that pierced a shield and the battery pack, causing a fire. In the other fire, a driver in Mexico crashed into a concrete wall and a tree at a high speed.
The Model S has as a large battery pack under the passenger compartment, protected by a quarter-inch-thick metal shield. Experts say that if debris punctures the shield and damages the battery, it can cause shorts and arcing that can touch off fires.
The National Highway Traffic Safety Administration, the U.S. government's auto safety watchdog, says the agency will contact Tennessee authorities to determine if there are safety problems that need further action.
The driver in Tennessee was able to pull onto an emergency lane and escape. Tesla said it has sent a team to investigate.
Company spokeswoman Liz Jarvis-Shean says the fire was not spontaneous. She says Tesla contacted the driver, who believes the car saved his life.
The fire burned the front of the car, according to pictures posted on the Jalopnik.com and Valuewalk.com websites.
Larry Farley, Rutherford County fire chief, says the blaze was so hot and intense that it melted the front of the car. "It pretty much just melted to the road," Farley says.
The passenger compartment was in pretty good shape after the flames were extinguished, Farley says.
According to the U.S. Fire Administration, there are around 194,000 vehicle fires on U.S. roads each year. The vast majority -- 61 per cent -- start in the engine area, while 15 per cent start in the passenger area. Approximately 300 people die and 1,250 are injured in U.S. vehicle fires each year. Most happen in gas-powered cars, which make up the vast majority of cars on U.S. roads. Electric vehicles make up less than 1 per cent of the cars sold in the U.S.
General Motors and Nissan make the top-selling electric cars in the nation, the Volt and Leaf. Neither knows of any real-world blazes in those vehicles. A Chevrolet Volt caught fire two years ago after a government crash test, but the government closed an investigation into the incident after GM agreed to a safety campaign to bolster shielding around the battery.
GM has sold more than 50,000 Volts in the U.S. since late 2010. Nissan has sold almost 38,000 Leafs. Tesla has sold an estimated 16,251 Model S cars in the U.S., according to Autodata Corp.
The Model S, which starts at $70,000, can go up to 265 miles on a single charge.
Shares of the carmaker, based in Palo Alto, Calif., fell 6.4 per cent Thursday afternoon to $141.52.
The high-flying stock had risen in value by more than 400 per cent earlier in the year, but fell this week. Concerns about a battery shortage, as well as the costs Tesla will incur as it builds more cars, spooked some investors after the company issued third-quarter earnings.
Associated Press Writers Bruce Schreiner in Louisville, Ky., Erik Schelzig in Nashville and Dee-Ann Durbin in Detroit contributed to this report.